| MATERIAL SAFETY
DATA SHEET |
| SECTION
1 - IDENTIFICATION |
| PRODUCT
NAME: Motion-Plus™ Combustion
Chamber Cleaner |
EMERGENCY
TELEPHONE:(786)) 336 0630 |
| TRADER
OWNER: M & J Sunshine Corporation |
INFORMATION
FAX:(786) 336 0629 |
TRADER
ADDRESS: 5220 NW 72nd Avenue #24
Miami, FL 33166 |
|
|
| SECTION
2 - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION |
| HAZARDOUS
COMPONENTS |
OSHA PEL |
ACGIH
TLV |
LIMITS RECOMMENDED |
CAS
NUMBER |
| Petroleum Hydrocarbons |
> 3% 500 ppm |
100 ppm |
STEL 200 ppm |
8052-41-3 |
| Aliphatic Alcohol |
> 3% 400 ppm |
|
|
67-63-0 |
| Petroleum Naphtha |
>3% |
|
NIOSH 100 mg/m3/hr |
8008-20-6 |
| This
product does not contain any chemical listed as a carcinogen or mutagen
by OSHA, IARC Monographs or the National Toxicology Program; does
not contain any ozone depleting substances or heavy metals and complies
with the RCRA Clean Air Act of 1991. |
|
| SECTION
3 - PHYSICAL/CHEMICAL CHARACTERISTICS |
CHEMICAL
NAME: Petroleum hydrocarbons plus additives
BOILING POINT: > 320oF
VAPOR PRESSURE: 6.75 mm Hg
VAPOR DENSITY: 3.92
SOLUBILITY IN WATER: Partial
APPEARANCE AND ODOR: Icy clear blue/mild petro-alcohol
|
SPECIFIC
GRAVITY: 0.801
MELTING POINT: N/A
EVAPORATION RATE: < 0.5 |
|
| SECTION
4 - FIRE AND EXPLOSION HAZARD DATA |
FLASH
POINT AND METHOD USED: 101°F PMCC
FLAMMABLE LIMITS: Lower: 7% Upper: 0.8%
EXTINGUISHING MEDIA: Foam, chemical, CO2, waterfog
|
SPECIAL
FIRE FIGHTING PROCEDURES:
Wear self-contained breathing apparatus. Do not use water except as
fog
UNUSUAL FIRE AND EXPLOSION HAZARDS:
Vapors may travel along ground to ignition sources; do not use welder
or cutting torch on drums
|
|
| SECTION
5 - REACTIVITY DATA |
STABILITY:
Stable under normal conditions
CONDITIONS TO AVOID: Ignition sources, sparks, open flame
INCOMPATIBILITY (materials to avoid): Strong oxidizers |
HAZARDOUS
DECOMPOSITION/BYPRODUCTS: CO2, CO, hydrocarbons
HAZARDOUS POLYMERIZATION: Will not occur |
|
| SECTION
6 - HEALTH HAZARD DATA |
| PERMISSIBLE CONCENTRATIONS:
500 ppm |
| ACUTE TOXICOLOGICAL
PROPERTIES: Vapor irritates eyes, nose and throat. |
| CHRONIC EFFECTS
OF OVEREXPOSURE: Irritation of eyes, nose, throat; dizziness; dermatitis;
nausea; vomiting |
|
EMERGENCY & FIRST AID PROCEDURES:
Eyes: Immediately
flush with large quantities of water for at least 15 minutes and
call a physician if irritation persists.
Skin: Wash area thoroughly with soap and water.
Inhalation: Remove exposed person to fresh air and ventilate area.
Ingestion: Call a physician. Do NOT induce vomiting. Aspiration
into the lungs can cause chemical pneumonia
|
|
| SECTION
7 - CONTROL MEASURES |
PROCEDURE FOR
CLEAN UP:
Eliminate sources of ignition. Ventilate area. Absorb with sand or
inert material.
Prevent liquid from entering sewer, watercourses or low areas. |
WASTE DISPOSAL
METHOD:
Dispose of in accordance with all applicable Federal, State and Local
regulations. |
PRECAUTIONS FOR
HANDLING AND STORING:
Keep away from open flames and other ignition sources. Keep container
closed until ready for use. |
|
| SECTION
8 - PRECAUTIONS FOR SAFE HANDLING AND USE |
| VENTILATION:
Local exhaust - Face velocity > 60 cf/m in confined area |
| RESPIRATORY
PROTECTION: Use SCBA in confined areas |
| PROTECTIVE
GLOVES: Chemical resistant |
| EYE
PROTECTION: Chemical safety goggles |
| OTHER
PROTECTIVE EQUIPMENT/CLOTHING: Usually not needed |
| WORK/HYGIENIC
PRACTICES: Use usual, good hygienic practices; wash thoroughly after
use. |
|
| SECTION
9 - NFPA RATING |
| HEALTH: 2 |
FIRE: 2 |
REACTIVITY: 0
|
SPECIAL: 1 |
|
| SECTION
10 - TRANSPORTATION |
DOT ID
No.: UN 1993
DOT LABEL REQUIRED: Flammable Liquid
FREIGHT CLASSIFICATION: Flammable Liquid, NOS, contains isopropanol
HAZARD CLASS: 3
PACKING GROUP: PGIII
The information and recommendations contained herein are based upon data
believed to be correct. However, no guarantee or warranty of any kind, expressed
or implied, is made with respect to the information contained herein. This
Material Safety Data Sheet was prepared to comply with the OSHA Hazard Communication
Standard (29 CFR 1910.1200). This supersedes any previous information. |
