| MATERIAL SAFETY
DATA SHEET |
| SECTION
1 - IDENTIFICATION |
| PRODUCT
NAME: Motion-Plus™ Oil System
Cleaner |
EMERGENCY
TELEPHONE: (786) 336 0630 |
| TRADER
OWNER: M & J Sunshine Corporation |
INFORMATION
FAX: (305) 3336 0629 |
TRADER
ADDRESS: 5220 NW 72nd Avenue #24
Miami, FL 33166 |
|
|
| SECTION
2 - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION |
| HAZARDOUS
COMPONENTS |
OSHA PEL |
ACGIH
TLV |
LIMITS RECOMMENDED |
CAS
NUMBER |
| Naphthenic Oil |
> 5mg/M3 as
min oil |
Same |
None |
64742-52-5 |
| Xylene |
> 100 |
100 |
None |
68008-20-6 |
| Petroleum Naphtha |
> 5mg/M3 as
min oil |
Same |
None |
8008-20-6 |
| 2-Butoxyethanol |
> 25 ( skin
) |
20 |
None |
111-76-2 |
| |
|
| SECTION
3 - PHYSICAL/CHEMICAL CHARACTERISTICS |
BOILING
POINT: 279-580oF ( range)
VAPOR PRESSURE : PSIG @ 70 oF ( Aerosols )
VAPOR DENSITY (air = 1): N/E
SOLUBILITY IN WATER: Partial
AAPPEARANCE AND ODOR: Viscous amber liquid with slight solvent odor.
|
SPECIFIC
GRAVITY: 0.90
Water Reactivity: No
EVAPORATION RATE: N/E |
|
| SECTION
4 - FIRE AND EXPLOSION HAZARD DATA |
FLASH
POINT AND METHOD USED: 140oF -200oF PMCCC
FLAMMABLE LIMITS: Lower: N/E Upper: N/E
EXTINGUISHING MEDIA: Foam, dry chemical, use water spray to cool exposed
surfaces.
|
SPECIAL
FIRE FIGHTING PROCEDURES:
Use waterspray to cool fire-exposed surface and to protect personnel
UNUSUAL FIRE AND EXPLOSION HAZARDS:
Cool containers with water to prevent rupturing. Vapors may spread
to distant ignition sources (pilot lights, welding equipment, electrical
equipment, etc.) and flash back.
|
|
| SECTION
5 - REACTIVITY DATA |
STABILITY:
Stable under normal conditions
CONDITIONS TO AVOID: Open flame, welding arcs, heat, sparks.
INCOMPATIBILITY Acids and strong oxidizers. |
HAZARDOUS
DECOMPOSITION/BYPRODUCTS: Includes but not limited to smoke, fumes,
carbon monoxide, various hydrocarbons.s
HAZARDOUS POLYMERIZATION: Will not occur |
|
| SECTION
6 - HEALTH HAZARD DATA |
| ROUTE(S) OF ENTRY:
Inhalation? Yes Skin? Limited Ingestion? Yes (deliberate) |
| HEALTH HAZARDS-ACUTE
TOXICOLOGICAL PROPERTIES: Inhalation: May cause headache, dizziness,
asphyxia, anesthetic effects and possible unconsciousness. Skin: Prolonged
contact may be irritating. Ingestion: Nauseas, vomiting and diarrhea;
possible chemical pneumonitis if aspired into lungs. |
CHRONIC EFFECTS:
Chronic overexposure have been suggested as a cause of mild, reversible
liver effects, cardiac sensitization, kidney damage, effects on
hearing, CNS damage, and blood abnormalities in laboratory animals.
|
| MEDICAL CONDITIONS
GENERALLY AGGRAVATED BY EXPOSURE: May aggravate existing eye, skin
or upper respiratory conditions. |
|
EMERGENCY & FIRST AID PROCEDURES:
Eyes:
Immediately flush with large quantities of water for at least
15 minutes and call a physician if irritation
persists.
Skin: Wash thoroughly with soap and water.
Inhalation: Remove exposed person to fresh air
and ventilate area.
Ingestion: Call a physician. Do NOT INDUCE VOMITING.
Never give anything by mouth to an unconscious person.
|
|
| SECTION
7 - CONTROL MEASURES |
WASTE DISPOSAL
METHOD:
Dispose of in accordance with all applicable Federal, State and Local
regulations. |
PRECAUTIONS FOR
HANDLING AND STORING:
Keep container closed until ready for use. Keep away from feed
and food products. Do not handle or store near flame, high heat or
strong oxidizers. Adequate ventilation required. |
OTHER PRECAUTIONS:
:
Do not store or handle in temperatures above 100oF. |
|
| SECTION
8 - PRECAUTIONS FOR SAFE HANDLING AND USE |
| RESPIRATORY
PROTECTIONS: Use proper MSHA/NIOSH respirators or SCBA in confined
space |
| VENTILATION:
Local exhaust - Face velocity > 60 fpm in confined area Mechanical
(general) - explosion-proof ventilation equipment Special - none -
Other adequate ventilation - no smoking or other sparks. |
| PROTECTIVE
GLOVES: Disposable nitrile gloves are suggested. |
| EYE
PROTECTION: Chemical safety glasses. |
| OTHER
PROTECTIVE EQUIPMENT/CLOTHING: Eyewash station. |
| WORK/HYGIENIC
PRACTICES: Do not eat, drink or smoke in work area. Wash hands after
handling. |
|
| SECTION
9 - NFPA RATING |
| HEALTH: 1 |
FIRE: 2 |
REACTIVITY: 10
|
SPECIAL: None |
|
| SECTION
10 - TRANSPORTATION |
DOT ID
No.: Not regulated.
DOT LABEL REQUIRED: None
FREIGHT CLASSIFICATION: None
HAZARD CLASS: 2
PACKING GROUP: PGIII
The information and recommendations contained herein are based upon data
believed to be correct. However, no guarantee or warranty of any kind, expressed
or implied, is made with respect to the information contained herein. This
Material Safety Data Sheet was prepared to comply with the OSHA Hazard Communication
Standard (29 CFR 1910.1200). This supersedes any previous information. |
