| MATERIAL SAFETY
DATA SHEET |
| SECTION
1 - IDENTIFICATION |
| PRODUCT
NAME: Motion-Plus™ Fuel Treatment
|
EMERGENCY
TELEPHONE: (786) 336 0630 |
| TRADER
OWNER: M & J Sunshine Corporation |
INFORMATION
FAX: (786) 336 0629 |
TRADER
ADDRESS: 5220 NW 72nd Avenue #24
Miami, FL 33166 |
|
|
| SECTION
2 - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION |
| HAZARDOUS
COMPONENTS |
OSHA PEL |
ACGIH
TLV |
LIMITS RECOMMENDED |
CAS
NUMBER |
| Aliphatic Alcohol |
> 3% 400 ppm |
|
None |
67-63-0 |
| Aliphatic Hydrocarbons |
>3% |
|
NIOSH-100 mg/m3/10
hr |
8008-20-6 |
| Petroleum Naphtha |
>3% |
|
NIOSH-100 ppm
TOV |
8030-30-6 |
| This
product does not contain any chemical listed as a carcinogen or mutagen
by OSHA, IARC Monographs or the National Toxicology Program; does
not contain any ozone depleting substances or heavy metals and complies
with the RCRA Clean Air Act of 1991. |
|
| SECTION
3 - PHYSICAL/CHEMICAL CHARACTERISTICS |
BOILING
POINT: >189oF
VAPOR PRESSURE (mm Hg): 104 at 38oC
VAPOR DENSITY (air = 1): 2.40
SOLUBILITY IN WATER: 70% soluble
|
SPECIFIC
GRAVITY: 0.80
MELTING POINT: N/A
EVAPORATION RATE: 2.14
APPEARANCE AND ODOR: Very light viscous liquid, light green in appearance,
alcohol-type odor |
|
| SECTION
4 - FIRE AND EXPLOSION HAZARD DATA |
FLASH
POINT AND METHOD USED: 62oF PMCC/120oF COC
FLAMMABLE LIMITS: Lower: 2% Upper: 12%
EXTINGUISHING MEDIA: Foam, chemical, CO2
|
SPECIAL
FIRE FIGHTING PROCEDURES: Use waterspray to cool fire-exposed surface
and to protect personnel
UNUSUAL FIRE AND EXPLOSION HAZARDS: Respiratory protection (NIOSH
approved) for fire fighting personnel.
Cool with water; no unusual products of combustion.
|
|
| SECTION
5 - REACTIVITY DATA |
STABILITY:
Stable under normal conditions
CONDITIONS TO AVOID: Open ignition sources
INCOMPATIBILITY (materials to avoid): Alkylene oxides, acid and hydrides,
inorganic and organic acids, strong
oxidizing agents, phosphorous trichloride monomers, aldehydes, polymerizable
esters, hydrogen with palladium
|
HAZARDOUS
DECOMPOSITION/BYPRODUCTS: None
HAZARDOUS POLYMERIZATION: Will not occur
CONDITIONS TO AVOID: None known
|
|
| SECTION
6 - HEALTH HAZARD DATA |
| ROUTE(S) OF ENTRY:
Inhalation? Yes Skin? Limited Ingestion? Yes (deliberate) |
| HEALTH HAZARDS-ACUTE
TOXICOLOGICAL PROPERTIES: Vapor irritates eyes, nose and throat. Ingestion:
May cause depression of central nervous system. Skin: Prolonged contact
may be irritating. |
| CARCINOGENICITY:
None NTP? No IARC Monographs? No OSHA Regulated? No |
SIGNS & SYMPTOMS
OF EXPOSURE: Eyes: Red and drowsy; dizziness, altered personality,
nausea, vomiting.
Exhibits signs of acute to chronic drunkenness. |
| MEDICAL CONDITIONS
GENERALLY AGGRAVATED BY EXPOSURE: Alcoholism (direct ingestion) |
| EMERGENCY
& FIRST AID PROCEDURES:
Eyes: Immediately flush with large quantities of water for at least
15 minutes and call a physician if irritation
persists.
Skin: Wash thoroughly with soap and water.
Inhalation: Remove exposed person to fresh air and ventilate area.
Ingestion: Call a physician. Do NOT induce vomiting. Never give
anything by mouth to an unconscious person. |
|
| SECTION
7 - CONTROL MEASURES |
STEPS TO BE TAKEN
IN CASE MATERIAL IS RELEASED OR SPILLED: Eliminate sources of ignition.
Prevent
liquid from entering sewers, watercourses or low areas. Adequately
ventilate area. Recover free liquid by pumping, or use a suitable
absorbent (vermiculite). |
| WASTE DISPOSAL
METHOD: Dispose of in accordance with all applicable Federal, State
and Local regulations. |
PRECAUTIONS FOR
HANDLING AND STORING: Keep container closed until ready for use. Keep
away from feed
and food products. Do not handle or store near flame, high heat or
strong oxidizers. Adequate ventilation required. |
| OTHER PRECAUTIONS:
Do not store or handle in temperatures above 100oF. |
|
| SECTION
8 - PRECAUTIONS FOR SAFE HANDLING AND USE |
| RESPIRATORY
PROTECTIONS: Use proper OSHA/NIOSH respirators or SCBA in confined
space |
VENTILATION:
Local exhaust - Face velocity > 60 fpm in confined area
Mechanical (general) - explosion-proof ventilation equipment
Special - none
Other adequate ventilation - no smoking or other sparks |
| PROTECTIVE
GLOVES: Chemical resistant |
| EYE
PROTECTION: Chemical safety goggles |
| OTHER
PROTECTIVE EQUIPMENT/CLOTHING: Usually not needed |
| WORK/HYGIENIC
PRACTICES: Use usual, good hygienic practices; wash thoroughly after
use. |
|
| SECTION
9 - NFPA RATING |
| HEALTH: 2 |
FIRE: 3 |
REACTIVITY: 0
|
SPECIAL: 0 |
|
| SECTION
10 - TRANSPORTATION |
DOT ID
No.: UN 1993
DOT LABEL REQUIRED: Flammable Liquid
FREIGHT CLASSIFICATION: Flammable Liquid, NOS, contains isopropanol
HAZARD CLASS: 3 PACKING GROUP: PGIII The
information and recommendations contained herein are based upon data believed
to be correct. However, no guarantee or warranty of any kind, expressed
or implied, is made with respect to the information contained herein.
This Material Safety Data Sheet was prepared to comply with the OSHA Hazard
Communication Standard (29 CFR 1910.1200). This supersedes any previous
information. |
